Samlexpower PST-120-12 Owner's Manual

DC-AC Power Inverter Pure Sine Wave PST-1500-12PST-1500-24PST-2000-12PST-2000-24Please read this manual BEFORE installing your inverterOwner's

10 | SAMLEX AMERICA INC. Power Rating of the Inverters

10 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 11TABLE 2.1: INVERTER SIZING FACTORType of Device or ApplianceInverter Sizing Factor*

12 | SAMLEX AMERICA INC. SECTION 4 | Powering Direct / Embedded Switch Mode Power Supplies (SMPS)

12 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 13SECTION 4 | Powering Direct / Embedded Switch Mode Power Supplies (SMPS)Fig 4.1

14 | SAMLEX AMERICA INC. SECTION 5 | Principle of Operation

14 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 15SECTION 6 | LayoutFig. 6.1: Layout of PST-1500 and PST-2000LN1216151413PST-1500 &

16 | SAMLEX AMERICA INC. 1. 

16 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 17SECTION 7 | General Information on Batteries for Powering InvertersTypical Bat

18 | SAMLEX AMERICA INC. SECTION 7 | General Information on Batteries for Powering Inverters

18 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 19SECTION 7 | General Information on Batteries for Powering InvertersFig. 7.1:

2 | SAMLEX AMERICA INC. OWNER'S MANUAL | IndexSECTION 1 Safety Instructions ...3SECTION 2 General

20 | SAMLEX AMERICA INC. 

20 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 21SECTION 7 | General Information on Batteries for Powering Inverters

22 | SAMLEX AMERICA INC. 

22 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 23SECTION 7 | General Information on Batteries for Powering Inverters

24 | SAMLEX AMERICA INC. 

24 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 25SECTION 7 | General Information on Batteries for Powering Inverters

26 | SAMLEX AMERICA INC. 

26 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 27SECTION 8 | Installation WARNING! 

28 | SAMLEX AMERICA INC. The corrosive fumes will corrode and damage the unit and if the gases are not venti-

28 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 29SECTION 8 | Installation105.641534107.51.2263107.51.25253519.2200468.2510510Fig. 8.1 P

2 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 3SECTION 1 | Safety InstructionsThe following safety symbols will be used in this manual

30 | SAMLEX AMERICA INC. DC Side ConnectionsPreventing DC Input Over Voltage

30 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 31SECTION 8 | Installationterminal of the inverter ► 

32 | SAMLEX AMERICA INC. can ow from the battery to the p

32 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 33NOTE: Thicker wire may be selected if lower voltage drop is desired.Table 8.1 Wiring Res

34 | SAMLEX AMERICA INC. AC SIDE CONNECTIONS WARNING! Preventing Paralleling of the AC Output

34 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 35SECTION 8 | Installation 

36 | SAMLEX AMERICA INC. AC Output Cable Sizing & Conductor Termination for Hard-wiring

36 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 37SECTION 9 | OperationSwitching The Inverter ON/OFF

38 | SAMLEX AMERICA INC. SECTION 10 | ProtectionsThe inverter has been provided with protections detailed below:Overload / Short Circuit Shut

38 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 39Over-Temperature Shut Down In case of failure of the cooling fans or in the case of inad

4 | SAMLEX AMERICA INC. SECTION 1 | Safety InstructionsPreventing re and explosion hazards  

40 | SAMLEX AMERICA INC. SECTION 11 | Trouble Shooting GuideISSUE POSSIBLE CAUSE REMEDYWhen switched ON, The GREEN "Power ON"LED (2)

40 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 41ISSUE POSSIBLE CAUSE REMEDYThere is no AC output. The GREEN "Power ON" LED (2)

42 | SAMLEX AMERICA INC. SECTION 12 | SpecicationsMODEL NO. PST-1500-12 PST-1500-24OUTPUT  

42 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 43! CAUTION! RISK OF FIRE

44 | SAMLEX AMERICA INC. SECTION 12 | SpecicationsMODEL NO. PST-2000-12 PST-2000-24OUTPUT  

44 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 45SECTION 12 | Specications! CAUTION! RISK OF FIRE

46 | SAMLEX AMERICA INC. SECTION 13 | Warranty2 YEAR LIMITED WARRANTY

46 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 47NOTES:

Contact InformationToll Free NumbersPh: 800 561 5885Fax: 888 814 5210Local NumbersPh: 604 525 3836Fax: 604 525 5221Websitewww.samlexamerica.comUSA

4 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 5SECTION 1 | Safety Instructions

6 | SAMLEX AMERICA INC. SECTION 2 | General Information 

6 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 7

8 | SAMLEX AMERICA INC. creating overload. Reactive L

8 | SAMLEX AMERICA INC. SAMLEX AMERICA INC. | 9SECTION 2 | General Informationfrequency harmonic content in a modied sine wave produce